March 30th, 2018

Check Out the Legendary .009″ Group By Mac McMillan

Mac McMillan .009 benchrest record group nbrsa

Mac McMillan .009 benchrest record group nbrsa.009″ — The Record That Stood for 40 Years.
In 1973 Mac McMillan shot an amazing 100-yard, .009″ five-shot group in a benchrest match. The .009″ group was measured with a 60x microscope for verification. Mac McMillan shot the group using a handbuilt prototype McMillan rifle with an early McMillan stock.

Mac’s .009″ group was the “Holy Grail” of rifle accuracy. This .009″ record was considered by many to be unbreakable, a record that would “stand for all time”. Well, it took 40 years, but someone finally broke Mac’s record with an even smaller group. In 2013, Mike Stinnett shot a .0077″ five-shot group using a 30 Stewart, a .30 caliber wildcat based on the 6.5 Grendel. Stinnett’s .0077″ group now stands as the smallest 100-yard group ever shot in registered benchrest competition.*
Read About .0077″ group HERE.

Stinnett’s success doesn’t diminish the significance of Mac McMillan’s .009″ group in the history of benchrest competition. For four decades Mac’s group stood as the ultimate standard of rifle accuracy*. For those of you who have never seen Mac McMillan’s .009″ group, here it is, along with the NBRSA World Record certificate. The target now hangs in the McMillan Family Museum.

Mac McMillan .009 benchrest record group nbrsa

*Somebody else might claim a smaller group, but unless moving backers or electronic targets were used, it cannot be verified. Moving target backers are used at registered benchrest matches to ensure that five (5) shots are actually fired in each group. That eliminates any doubt.

Permalink Competition, News, Shooting Skills 10 Comments »
August 15th, 2013

Inside Look at World Record .0077″ Group — The Gun and Ammo

We reported two weeks ago that Texas shooter Mike Stinnett nailed a .0077″ group in competition — the smallest 5-shot group ever shot at 100 yards. This has now been officially recognized as a new NBRSA record, eclipsing the .009″ record group shot 40 years ago by Mac McMillan. Congrats to Mike for breaking the “unbreakable record”. As Glenn C. posted on Benchrest Central: “They said it couldn’t be done. Hats off to Mike for an awesome personal achievement in a Sport/Hobby where getting your name in the record books is a rarity.”

kelbly speedy shorty panda action

Stinnett Sets .0077″ Record with a .30-Caliber Modified Grendel Cartridge, Pre-Loaded
Many folks have asked about the gun and ammo that produced the .0077″ group. The rifle was chambered as a .30-caliber wildcat, the 30 Stewart, which is based on the 6.5 Grendel case necked up. Mike was using Hodgdon H4198 powder behind BIB 114gr, 10-ogive bullets. Notably, the record-setting ammo was pre-loaded before the match. Unfortunately, we don’t have a photo of the target yet — it is still in the hands of the official NBRSA certification committee. However, Mike has been kind enough to tell us about his rifle and his load.

Mike Stinnett .0077″ Record Group Equipment Report

Mike reports: “Several guys have asked so here is my equipment listing. The hardware build actually started in 2008 with the goal of building two identical Benchrest rifles which could be used for both group and score. The idea was to shoot 6PPC and a 30 Cal without a base rifle change.”

Action: Kelby Panda “Speedy Shorty” with solid bolt and PPC-diameter bolt face. Kelby was asked to build several actions which were identical with the intent to eliminate any variance in head space between the two new rifles. This helped me use a single set-up on sizing dies for both rifles and ammo is interchangeable. Both actions were sent to Thomas ‘Speedy’ Gonzalez to be blue-printed and have Jewell triggers installed.

Reamer: 30 STEWART (I just call it a 30 PPC as that is what everyone expects, but it is in fact a custom design and Ralph deserves about 99% of the credit).

Barrels: Krieger was selected for the barrels. After discussions with Randy Robinett of BIB Bullets, a 1:17″ twist was identified as the correct, safe solution. Ralph Stewart has cut all my chambers using a custom-designed reamer. [Our goal] was consistent headspace and Ralph has been able to keep my barrels within .0002 variance. The barrel tuner also comes from Ralph Stewart.

  • Stock: Larson (including action bedding)
  • Scope: Leupold 45X Competition in Kelby Single Screw Tall Rings
  • Brass: Lapua (Base case is 6.5 Grendel)
  • Bullets: Randy Robinett (BIB) 30 Cal. 114gr, 10 Ogive (secondary bullet; primary is 112gr BIB)
  • Powder: H4198 – Stout Load with 2980 FPS Velocity
  • Front Rest: Farley Coaxial
  • Bags: Micro Fiber
  • Flags: Graham Wind Flags (large)

About the Cartridge — 30 Stewart (Based on Lapua 6.5 Grendel Parent Brass)
Mike explains: “Our goal was to shoot H4198 as the optimal powder for stability. There were several versions of the reamer before we settled on the current configuration. I am optimized for the 10 Ogive BIB bullet, powder to the base of the bullet. I found in testing the small 30-cal case did not like compression at all. The bullet is seated only 0.12″ into the case with zero freebore.

Cases were initially created with the .220 Russian (like a PPC) but I later decided it was better to build from the 6.5 Grendel. I size the brass and bump the shoulder back until it will fit into the chamber, fill to shoulder with International Clays, cotton wad packed on top. I have a fire-forming barrel. (I would not recommend this Clays and cotton wad method in a good barrel.) After initial fire-forming, I then mandrel the neck up the rest of the way to .30 caliber, turn the necks and trim.

It takes at least 8 firings to fully form a case! If you fire only three loads I find the brass does not have a sharp shoulder or any pressure on the bolt so any die selection is incorrect. Brass continues to harden well past 25 firings. I have match brass with well over 500 rounds fired, and I have never blown a case or neck yet (using my forming method).

For loading I use a Hornady Custom Shop Sizing Die and a Ralph Stewart Custom Seating Die. For those who are curious, yes the small group was fired with pre-loaded rounds. I do this now and then with local matches or may load 50 in a batch for one match.”

Mike wanted to thank his smiths, Randy Robinett, and all the folks involved in running the matches: “A big THANKS — as these are the guys that make our matches possible and without question maintain the integrity of the targets and record system. I was very fortunate to have all the right people in the right places for this match and my record. As for measurement – I only saw the target for about 10 seconds up close and can say I’m very happy I did not have to measure that group! Thanks again to everyone!” — Mike Stinnett

kelbly speedy shorty panda action

Permalink Competition, News, Reloading 5 Comments »
August 2nd, 2013

Mike Stinnett Breaks ‘Unbreakable Record’ with .0077″ Group

.0077 World record benchrest groupOne of the most remarkable shooting records — and one that has stood for four decades — is the 0.009″ five-shot group credited to Mac McMillan. The NBRSA Light Varmint Record of .009″ for five shots (at 100 yards) was set on 9/23/1973, forty years ago. Experts have considered that record “untouchable”, “unassailable” — in other words “unbreakable.”

Well records are meant to be broken. It appears that Texan Mike Stinnett has broken the “unbreakable” .009″ NBRSA record. Mike shot a .0077″ five-shot group at 100 yards in a registered short-range benchrest match at Denton, Texas. This will be a new NBRSA record (and all-time world record) if approved. Mike was shooting a .30-caliber cartridge, listed as a 30 PPC, but there’s some talk that the cases were formed from a Lapua 6.5 Grendel case. No matter — this is a mind-blowing accomplishment, particularly considering that Stinnett was shooting a .30-caliber gun, which has considerably more recoil than a 22 PPC or 6 PPC.

Forum member Wes J. (aka “P1ZombieKiller”) reports: “My buddy Mike Stinnett was just confirmed as having beat the world record LV group at 100 yards in a registered match. His group measured .0077″ and he did it with his 30 caliber.”

Wes adds: “Mike shoots thousands of rounds a year… I have sat on the bench right next to him several times, and he has rattled off five shots down range in a matter of 2-3 seconds, and the groups have measured in the .1s. The guy can flat shoot. His wind reading abilities are mind-blowing. When he gets the right condition, he is fast. REALLY FAST.”

NOTE: We will publish photos of Mike Stinnett and his target as soon as they are available.

Permalink Competition, News No Comments »