As an Amazon Associate, this site earns a commission from Amazon sales.

October 6th, 2011

Surprising Results in Dept. of Defense Lead-Free Primer Tests

The Weapons System Technology Analysis Center (WSTIAC), part of the U.S. Department of Defense (DoD), recently conducted a comparison test between standard primers and lead-free primers. The test procedure, along with the surprising test results, are discussed in the WSTIAC Journal (Vol. 11, No. 2).

Key Findings of the WSTIAC Primer Study Were:

1. Lead-Free primers suffered from significant delays in ignition.

2. Lead-Free large rifle primers had a “a much larger variation in peak blast pressure” than did lead-based large rifle primers.

3. Field tests showed 7.62×51 rounds loaded with lead-free primers to be less accurate than rounds loaded with lead-based primers.

4. So-called “match-grade” primers were NOT always more consistent in pressure than standard primers.

Russian Lead-Free Primers Tested
WSTIAC scientists did some pretty sophisticated testing, measuring the blast waves of lead free primers vs. standard primers. The lead-free primers, denoted as DDNP for their “Diazodinitrophenol” active ingredients, were matched up against commercially-available primers containing lead. Eight models of widely-used, lead-based primers were tested along with two DDNP-based Russian-made primers, a large rifle primer (model KVB-7E) and a small pistol primer (model KVB-9E). Brief field tests were also conducted with large rifle primers in loaded ammunition. Testers measured primer ignition times, bullet muzzle velocities, and accuracy on 200m targets.

Lead-Free Primers Were Less Reliable, with Less Uniform Pressure
While you’ll need to read the study to understand the full results, in a nutshell, the DDNP (lead-free) primers proved somewhat less reliable than standard primers. The study observed: “The most obvious difference between the lead-based and DDNP-based primers was a perceptible delay between firing pin strike and ignition in 15 of 19 shots with the DDNP-based primers (and one misfire); in contrast, there were no misfires or perceptible delays in ignition with the lead-based primer.” The scientists theorized that: “The delay in ignition in 6 of the 10 shots with the DDNP-based primer suggests that this primer is at the low end of strength needed to reliably ignite 46 grains of an extruded powder.” The study also noted that: “DDNP-based KVB-7E has a much larger variation in peak blast pressure than other primers.”

Lead-Free Primers Were Less Accurate in 7.62×51 Ammo
One very interesting finding related to accuracy. In field tests, 7.62×51 ammo loaded with lead-free primers was tested against ammo with lead-based primers (other components were identical). At 200m, the average 10-shot group size of 7.62×51 ammo with lead-free primers was 2.5 MOA vs. 1.8 MOA for ammo with lead-based primers. That 0.7 MOA difference may well be meaningful (though we’d like to see the test repeated with multiple 10-shot groups, fired from a more accurate rifle). For precision shooters, this is a provocative finding because it suggests that a change in primer type, by itself, may have a dramatic impact on accuracy. The scientists surmised that: “ignition delay is the most likely cause of the larger average group size.”

“Match” Primers Are NOT Always More Consistent
One surprising collateral finding in the study challenges the widely-held notion that “Match Primers” are better, at least when judged by pressure uniformity. “Table 1 shows average peak pressures along with standard deviations from the mean for the primers in this study…. There are significant differences in the standard deviations observed for different primer types, and it is notable that so-called ‘Match’ primers are not always more consistent than non-match primers.” Readers should look at the bottom right of Table 1 below. Note that, as a percentage (%) of total pressure, the non-match CCI 450s have a significantly lower SD than the “Match” Fed 205m primers. On the other hand, the Federal 210M and 215M “Match” primers ARE more uniform in pressure than the non-match CCI Large Rifle primers.

ABSTRACT: Comparing Blast Pressure Variations of Lead-Based and DDNP (Lead-Free) Primers
This article describes the blast pressure waves produced by detonation of both lead styphnate and diazodinitrophenol (DDNP) based firearms primers measured with a high-speed pressure transducer located at the muzzle of a rifle (without powder or bullet). These primer blast waves emerging from the muzzle have a pressure-time profile resembling free-field blast pressure waves. The lead-based primers in this study had peak blast pressure variations (standard deviations from the mean) of 5.0-11.3%.

In contrast, lead-free DDNP-based primers had standard deviations of the peak blast pressure of 8.2-25.0%. Combined with smaller blast waves, these large variations in peak blast pressure led to delayed ignition and failure to fire in brief field tests.

Story Concept and Photos by German Salazar courtesy
Permalink Bullets, Brass, Ammo, News, Reloading 11 Comments »
October 6th, 2011

Western CMP Games & Creedmoor Cup Commence October 15

CMP Creedmoor Western GamesThe Western CMP Games/ Creedmoor Cup start very soon. From October 15-23, 2011, the Arizona State Rifle & Pistol Assn. will host the 8th Western CMP Games and Creedmoor Cup at the Ben Avery Range in Phoenix, AZ. The Western CMP Games Matches run from October 15 to 18. The Creedmoor Cup Matches take place on 19-23 October. All interested shooters, from novices to High Masters, are invited to participate. All entrants should pre-register. However, walk-ons will be allowed as range capacity permits.

CMP Creedmoor Western Games

CMP Creedmoor Western GamesThe Western CMP Games program includes clinics, individual rifle matches, Team Matches, Rimfire competition, and CMP rifle sales. The 8th Western CMP Games kick off with a New Shooter Clinic on 15 October followed by a 200-yard Garand-Springfield-Vintage Military Rifle Match that afternoon. On Sunday, 16 October, there will be an As-Issued M1 Garand EIC Match in the morning where shooters who do not have any EIC points can earn introductory “4-point legs.” That afternoon, there will be a Rimfire Sporter Match. The Rimfire Sporter Match is a low-key event that caters to all ages and skill levels.

On Monday, 17 October, there will be a second Garand-Springfield-Vintage Military Rifle Match that morning followed by an M1 Carbine Match that afternoon. The Western CMP Games Matches conclude on Tuesday, 18 October, with a third Garand-Springfield-Vintage Military Rifle Match, and Vintage Sniper Test Match. For more info on the CMP Games, contact the CMP at or call (888) 267-0796, ext. 1114.

Creedmoor Cup Clinic and Matches
The Creedmoor Cup matches will take place on 19-23 October, starting with a High Power Rifle Clinic offering lectures, demonstrations and dry line firing. Creedmoor Cup matches include a Zeroing Match, an EIC Match, a 2400 Aggregate Match and a Team Match. New This Year: The Creedmoor Cup will not longer be a one-day, 80-shot (800 point) match. It will not be a 240-shot (2400 point) Aggregate fired over three days. The 50-shot team match will now be fired on Sunday prior to the start of the EIC Match.For more information on the Creedmoor Cup Matches, contact Dennis DeMille at demille [at] or call (800) 273-3366.

Permalink Competition, News No Comments »